Pumps for Irrigation and Rainwater Harvesting
Pumps For Irrigation And Rainwater Harvesting
Find out how to choose a submersible pump for irrigation and rainwater collection systems
water | shopping | general
A
pump is the key component in most
irrigation,
rainwater toilet flush, and
greywater systems. The commonest requirement is to shift volumes of water from a large collection/storage tank to a
header tank from which it is used to water crops or gravity feed toilet cisterns.
Mains Power or Low Voltage Pumps
The first choice to make is whether to purchase a
mains powered pump, or a
low voltage (typically 12V) one.
Cable Size
A 300W mains powered pump draws a current of below 2 Amps and so quite
thin cable can be used - e.g. the cheap 5A-rated
twin and earth cable used in domestic lighting circuits would be perfect. A 300W 12V pump on the other hand would draw a current of over 25 Amps and so
thick cable would be required - very expensive with the price of copper where it is, particularly over long runs. (Visit our
Line Losses Calculator for a rough idea of the diameter of cable required for low voltage pumps).
Pump Cost and Quality
In general a mains powered pump will
cost less than an equivalent low voltage pump for all but the smallest of pumps. There are more mains powered pumps manufactured and sold than low voltage pumps which explains the difference in
price, but low voltage pumps tend to be better made from
higher quality materials than mains powered pumps as they are typically designed to be used in harsher conditions - e.g. outdoors and marine environments.
Float Switches
It is very useful to purchase a pump with a built in
float switch. This will automatically cut the power to the pump when there is no water left to pump thereby protecting the pump from being badly damaged and/or burnt out by
running dry. Mains powered pumps are more likely than low voltage pumps to come with an
integrated float switch - probably because a float switch on a low voltage pump has to switch a high current necessitating either an expensive float switch or added electronics (which can go wrong!).
Submersible pumps are much more likely to have integrated float switches than other pumps.
If using a pump without an integrated float switch, a suitable
float switch (
REUK Shop) should be fitted to the water tank
above the pump inlet to protect the pump. This will add to the cost and complexity of any
pump controller. (See our articles
Automatic Pump Shut Off Circuit, and
Simple Sump Pump Controller.)
Hidden Costs
If a pump is to be switched by a
relay then a
qualified electrician must make any high voltage connections. Therefore the cost of an electrician must be deducted from the initial savings of purchasing a mains powered pump. Future maintenance must be also be considered as an electrician could be required again.
Head and Flow Rate
The ability of a pump to pump is given by its
head and
flow rate. The
head is the maximum height to which a pump can pump water.
In the UK most pumps are sold with the
head specified in
metres or
feet, or alternatively the water
pressure generated by the pump measured in
psi (pounds per square inch).
To convert from
head to psi:
pressure (psi) = 0.434 * head (feet)
pressure (psi) = 0.132 * head (metres)
To convert from
psi to head:
head (feet) = 2.31 * pressure (psi)
head (metres) = 0.705 * pressure (psi)
When
selecting a pump, you need to measure the height difference between the pump's water inlet, and the highest point the water is to be pumped. The
head of the pump chosen must be greater than that measured distance, ideally by at least 25% so the pump is not over-worked.
The
flow rate is a measure (typically in litres or gallons per minute) of the amount of water which can be pushed out of the pump. This flow rate falls when water must be pumped upwards - i.e. a pump with a head of 5 metres and a flow rate of 10 litres per minute, will have a flow rate of 0 litres per minute if the water is to be pumped 5 metres or higher.
For non-submersible pumps, a further measure is
lift. This tells you the maximum difference in height between the pump, and the end of the pipe connected to the pump inlet.
Buying a Pump
A huge range of
pumps are listed for sale on
eBay UK. Click here to search for
Submersible Pumps in the UK (with the 100's of matching results for aquarium and fish pond pumps removed), or here for the same search on
eBay USA.
More Information
In order to protect your pump from
multi-switching - i.e. turning on and off rapidly - have a look at our article
Water Pump Hysteresis Circuit
Article Last Modified: 15:16, 19th Aug 2008Comment on this Article
If you have any comments on this article, please email them to
neil@reuk.co.uk.
Recommended Related Articles
People who read this article also enjoyed the following articles:
Rainwater Toilet Flush SystemFind out how to put together a complete rainwater fed toilet flushing system
Article Last Modified: 15:16, 19th Aug 2008water | general | electronicsSolar Powered IrrigationWater your garden or allotment with a solar powered irrigation system
Article Last Modified: 15:58, 12th Jun 2008solar | waterWater Pump Hysteresis CircuitA simple circuit to prevent a pump being damaged by being turned on and off rapidly (multiswitching)
Article Last Modified: 14:54, 19th Nov 2007water | electronics | electric circuitAutomatic Pump Shut Off CircuitPut together an automatic system to switch off a pump when there is no more fluid left to pump
Article Last Modified: 14:54, 19th Nov 2007water | electric circuitSimple Sump Pump ControllerPut together a sump pump controller with two float switches and NO electronics
Article Last Modified: 08:58, 5th Aug 2008water | electric circuit | electronicsCollect RainwaterDon't waste the rain water that falls on your home. Use it.
Article Last Modified: 16:09, 1st Jun 2007waterFloat Switch Water Level MeasurementFind out how to use float switches in renewable energy applications
Article Last Modified: 12:07, 28th Jul 2008water | electric circuitRainwater DiverterUse a rainwater diverter to send water collected in gutters to a water butt
Article Last Modified: 10:25, 30th May 2007water | shoppingPVC Wind Turbine BladesLearn how to make your own PVC wind turbine blades
Article Last Modified: 15:16, 19th Aug 2008windFlush Toilet with Rain WaterFlush your toilet with collected rain water
Article Last Modified: 15:09, 21st Feb 2008water | education | general
|
|
|
