Make Your Own Air Conditioner
Make Your Own Air Conditioner
Find out how to construct a simple cheap air conditioning system
general | geothermal20% of all electricity in the USA is used by
air conditioning units. The power consumption of air conditioners renders them incompatible with all but the largest domestic renewable energy systems, and so people living
off-grid typically have to do without.
In this article we will look at how a very cheap and simple room cooler can be put together, powered by a
12 Volt battery or directly from a
PV Solar Panel.
DIY Groundsource Heat Pump Cool Fan
Once you dig more than a few feet down, the temperature of the ground is pretty much constant throughout the year. This is the key to
Geothermal (Groundsource) Heat Pumps - systems which keep buildings cool in the summer and warm in the winter with great efficiency. Using this fact it is possible to put together a simple room cooler using nothing more than thin
plastic tubing, a small
circulation pump, a
fan, and a few fittings.
A coil of plastic tubing is buried 1+ metres below ground level where it will find consistent temperatures of around 11-12 degrees Celcius year-round. It is connected through a hole drilled in the wall (or through a window / ventilation brick) to the fan via a
closed loop. The hose, or ideally
copper tubing is wound around in a spiral at the back of the fan, so the air drawn into the fan is pre-cooled to below the ambient summer air temperature.
The tubing can be attached to the grille of the fan very easily using
cable ties.
Anti-freeze or heavily salted water is ideal to act as the
coolant pumped around the system since it will not freeze when the system lies dormant in the winter. Since the air in the room is hotter than the air in the ground, the
coolant takes heat from the air before it is blown out from the fan and then deposits it in the ground. This set up is a basic
heat exchanger.
Any small
circulation pump can be used to move the coolant around the system. 12V aquarium pumps can be perfect, as can the pumps typically used in
solar water heating systems, and in ornamental garden water fountains. All of these pumps have very low power consumption, and can be powered with a
12V battery.
Super Cooling Homemade Air Conditioner
If more
rapid cooling is required, and energy efficiency is not such an issue, then an alternative to using the ground as a source of cool is to use an insulated container filled with
icy salt water. Using a copper coil in the icy water, a copper coil at the front AND rear of the fan, and flexible tubing to complete the loop (via the pump), a hot room can be cooled to a comportable level in 10-20 minutes.
Here are a couple of useful related links:
Homebrew Air Conditioning
Pete H's Homemade Air Conditioner
Related REUK Articles
Heating is as much if not more of an energy hog than cooling. Take a look at our article
Make a Simple Solar Air Heater to find out how you can greatly reduce your heating bills.
Article Last Modified: 13:36, 14th Nov 2007Comment on this Article
If you have any comments on this article, please email them to
neil@reuk.co.uk.
Recommended Related Articles
People who read this article also enjoyed the following articles:
Make a Simple Solar Air HeaterHeat a room or outhouse with a solar heater made from recycled aluminium cans
Article Last Modified: 14:55, 1st May 2007solar | heatingGeothermal Heat PumpFind out about using ground source heat pumps to heat your home
Article Last Modified: 13:57, 29th Jan 2009geothermal | energy efficiencyPermanent Magnet GeneratorBuild a wind or water power system with around a PM Generator
Article Last Modified: 11:44, 21st Jul 2008wind | hydroSimple Solar Water HeatingMake a simple solar water heater with easy to find materials
Article Last Modified: 13:17, 30th Jun 2008heating | solar | waterStirling Engine Solar PowerGenerate electricity from a solar powered Stirling Engine
Article Last Modified: 13:39, 17th Apr 2006solarBridge RectifierFind out more about bridge rectifiers.
Article Last Modified: 15:33, 2nd Feb 2007electronics | wind | waveBuild a Concentrated Solar Water HeaterPlans for building a cheap advanced solar water heating system
Article Last Modified: 10:14, 12th Apr 2007heating | solar | waterPVC Wind Turbine BladesLearn how to make your own PVC wind turbine blades
Article Last Modified: 15:16, 19th Aug 2008windDIY Solar Water HeatingBuild Your Own DIY Solar Water Heating Panel
Article Last Modified: 15:37, 21st Apr 2006heating | solarDIY 2kW Wind TurbineRead about a home built 2kW wind turbine constructed from scrap
Article Last Modified: 08:46, 4th Oct 2007wind | recycling
|
|
|
